DG130R-ARMA-3
主要產品：日本東方馬達，韓國DKM減速電機，泰映TROY減速電機，韓國SPG小功率
馬達，CPG晟邦減速電機 ...
銷售熱線: 180-6090-9625/0592-6013512
聯系人：蘭工
QQ: 869740621
減速機技術資料：
在選擇減速機的型號時應注意的幾個事項：盡量選用接近理想減速比：減速比=伺服馬達轉速/減速機出力軸轉速扭力計算：對減速機的壽命而言，扭力計算非常重要，并且要注意加速度的最大轉矩值（TP），是否超過減速機之最大負載扭力。
適用功率通常為市面上的伺服機種的適用功率，減速機的適用性很高，工作系數都能維持在1.2以上，但在選用上也可以以自己的需要來決定，要點有二：A.選用伺服電機的出力軸徑不能大于表格上最大使用軸徑；B.若經扭力計算工作，轉速可以滿足平常運轉，但在伺服全額輸出時，有不足現象時，我們可以在電機側之驅動器，做限流控制，或在機械軸上做扭力保護，這是很必要的。
通用減速機的選型包括提出原始條件、選擇類型、確定規格等步驟。
相比之下，類型選擇比較簡單，而準確提供減速器的工況條件，掌握減速器的設計、制造和使用特點是通用減速器正確合理選擇規格的關鍵。
規格選擇要滿足強度、熱平衡、軸伸部位承受徑向載荷等條件。
1.按機械功率或轉矩選擇規格（強度校核）通用減速器和專用減速器設計選型方法的最大不同在于，前者適用于各個行業，但減速只能按一種特定的工況條件設計，故選用時用戶需根據各自的要求考慮不同的修正系數，工廠應該按實際選用的電動機功率（不是減速器的額定功率）打銘牌；后者按用戶的專用條件設計，該考慮的系數，設計時一般已作考慮，選用時只要滿足使用功率小于等于減速器的額定功率即可，方法相對簡單。
通用減速器的額定功率一般是按使用（工況）系數KA=1（電動機或汽輪機為原動機，工作機載荷平穩，每天工作3~10h，每小時啟動次數≤5次，允許啟動轉矩為工作轉矩的2倍），接觸強度安全系數SH≈1、單對齒輪的失效概率≈1%，等條件計算確定的。
所選減速器的額定功率應滿足：PC=P2KAKSKR≤PN式中PC———計算功率（KW）；PN———減速器的額定功率（ KW）；P2———工作機功率（KW）；KA———使用系數，考慮使用工況的影響；KS———啟動系數，考慮啟動次數的影響；KR———可靠度系數，考慮不同可靠度要求。
目前世界各國所用的使用系數基本相同。雖然許多樣本上沒有反映出KS\ KR兩個系數，但由于知己（對自身的工況要求清楚）、知彼（對減速器的性能特點清楚），國外選型時一般均留有較大的富裕量，相當于已考慮了KR\ KS的影響。
由于使用場合不同、重要程度不同、損壞后對人身安全及生產造成的損失大小不同、維修難易不同，因而對減速器的可靠度的要求也不相同。系數KR就是實際需要的可靠度對原設計的可靠度進行修正。它符合ISO6336、GB3480和AGMA2001—B88（美國齒輪制造者協會標準）對齒輪強度計算方法的規定。目前，國內一些用戶對減速器的可靠度尚提不出具體量的要求，可按一般專用減速器的設計規定（SH≥1.25，失效概率≤1/1000），較重要場合取KR=1.25=1.56左右。
2、熱平衡校核通用減速器的許用熱功率值是在特定工況條件下（一般環境溫度20℃，每小時100%，連續運轉、功率利用率100%），按潤滑油允許的最高平衡溫度（一般為85℃）確定的。條件不同時按相應系數（有時綜合成一個系數）進行修正。
所選減速器應滿足：PCt=P2KTKWKP≤Pt式中 PCt———計算熱功率（KW）；母線加工機KT———環境溫度系數；KW———運轉周期系數；KP———功率利用率系數；Pt———減速器許用熱功率（KW）。
3.校核軸伸部位承受的徑向載荷通用減速器常常須對輸入軸、輸出軸軸伸中間部位允許承受的最大徑向載荷給予限制，應予校核，超過時應向制造廠提出加粗軸徑和加大軸承等要求。
(AB01) OMRON R88M-H30030-BS3 AC SERVO MOTOR WORKING
(AB01) MOTOR DRIVER OMRON PA204 SP001 X 8 WORKING
(AB01) CPU UNIT OMRON CS1H-CPU66-V1 SYSMAC CS1H WORKING
C120-SI022 Omron PLC New In Box C120 Expansion 3G2C4-SI022 C120SI022 3G2C4SI022
New Omron PLC RTD Input Card, CJ1W-PTS52
3G2C5-BC061 Omron PLC New In Box 6-Slot Rack 3G2C5BC061 C2000-BC061 C2000BC061
Omron E5ZT-N08TC01-2 Temperature Controller w/ E5ZT-W08-2 Power Controller Cable
Omron F10-C25 Amplifier Sensor 0.34 Amp 24VDC ! WOW !
OMRON SYSMAC C20-CPU74E PROGRAMMABLE CONTROLLER W/ C4K-ID POWER SUPPLY
C500-RT002-PEV1 Omron PLC New In Box 3G2A5-RT002-PEV1 3G2A5RT002PEV1 C500RT002
C200HE-CPU32-E Omron PLC New In Box CPU C200HECPU32E
Omron C40K-CDS1-A CPU Module 24VDC ! WOW !
(AG01) OMRON R88M-U10030LA-G11B AC SERVO MOTOR WORKING
C200H-DA004 Omron PLC New In Box Analog Out C200HDA004
Omron NT31-ST121B-EV2 Operator Interface Panel ! WOW !
SMI5-OC201TB Omron PLC New In Box S.MI5-OC201TB SMI5OC201TB SMI5-0C201T0
SMI5-ID021TB Omron PLC New In Box S.MI5-ID021TB SMI5ID021TB
E2CD-X5C3A Omron New In Box Prox Switch E2CDX5C3A
OMRON C500-CPU11-V1 (SYSMAC C500 PROGRAMMABLE CONTROLLER) GOOD TAKEOUT
Omron C200H-MC221 C200HMC221 Motion Control Module LNC
Omron PLC CJ1M-CPU13-ETN Ethernet CPU SYSMAC CJ1M CPU13-ETN
Omron V600-CA1A-V2 V600CA1AV2 ID System Controller NIB
OMRON 3G2C3-CPU11E C500 CONTROLLER W/ RAM / ROM UNIT
Omron V600-CA1A-N V600CA1AN ID System Controller NIB
Omron CS1W-MCH71 Motion Controller 32 Axis
OMRON CV500-RT211 REMOTE I/O UNIT GOOD TAKEOUT
OMRON R88D-UP04V USPP R88DUP04V
OMRON V530-R160EP 2D CODE READER 24 V DC W/ MANUAL PNP INPUT/OUTPUT NEW NO BOX
OMRON C500-ID219 3G2A5-ID219PLC INTPUT MODULE 24VDC 4CH
H# Omron CVM1-CPU11-EV2
OMRON Ultrasonic Sensor Amplifier E4DA-WL1C
OMRON CJ1WETN21 CJ1W-ETN21 Ethernet Module
Omron SYSMAC C1000H Programmable Controller CPU01-EV1
Omron HMI NP5-SQ001B NP5SQ001B NIB Free Ship
OMRON SRT2-OD32ML NEW
OMRON SRT2-MD32ML-1 NEW
OMRON SRT2-OD32ML-1 NEW
OMRON C20-LK201-EV1/3G2C7-LK201-EV1 HOST LINK UNIT ***XLNT***
OMRON VARISPEED V7 CIMR-V7AZB1P5 SPEC:B1P50 NEW
Omron NT31C-ST141B-E NT31CST141BE HMI Touch Panel
Omron NT30C-ST141B-E NT30CST141BE Disaply Screen
OMRON/AEC E5AX-VSS-AEC-320 TEMPERATURE CONTROLLER ***NIB***
Omron 3G8F5-CLK01
OMRON V600-CA5D01 ID Controller Free Ship
NEW OMRON PROGRAMMABLE CONTROLLER C500-OA223
Omron SCY-M1 CPU55 DI003 DO003 MD001 ID011 CN040 PLC
Omron 3F88L-132 Cam Positioner 3F88L132 Used
Omron CS1H-CPU63H CS1HCPU63H CPU Unit
Omron CS1W-SCU31-V1 Free Ship
Omron 3G2C5-GPC01E 3G2C5GPC01E GPC
OMRON C200HG-CPU43-E PLC CPU UNIT 16K W RS232 880 I/O
Omron C500-DA003 3G2A5-DA003
OMRON NS5-SQ00B-V1 USPP NS5SQ00BV1
OMRON C200H-CPU01-E2 NSPP C200HCPU01E2
Omron Sysmac CJ1G-CPU42H , CJ1W-ID211 , OC211 (J)
New Omron PLC CQM1H-PLB21
Omron #D4BL-3DRB 110VAC 50/60Hz Safety Door Lock Switch
Omron #D4BL-3DRB 110VAC 50/60Hz Safety Door Lock Switch
OMRON C200HW-DRM21 NSFP C200HWDRM21
OMRON 3G2C3-CPU11-E2-V1 NSPP 3G2C3CPU11E2V1
New Omron PLC Module CJ1W-CT021
Omron CV500-BI042 Base Unit Rack Chassis CV500BI042
OMRON 5" INTERACTIVE DISPLAY NS5-SQ01-V2 USED NS5SQ01V2
Omron C200HX-CPU54 C200HXCPU54 CPU Unit
Omron CV500-II101 I/O Interface Unit CV500II101
1 NIB OMRON R88D-UA20HA AC SERVO DRIVE 200V ANALOG
Omron F200-S Camera WITH Cosmicar 75mm Lens
OMRON CS1W-OD291 NSFP CS1WOD291
Omron NT30-ST131B-V1 Interactive Display Free Ship
Omron CJ1G-CPU43H New In Box CJ1GCPU43H Free Shipping worldwide
Omron CJ1G-CPU43H New In Box
OMRON 3G2S6-CPU16 USPP 3G2S6CPU16
OMRON PLC CP1H-Y20DT-D CP1HY20DTD NEW
OMRON 3G2S6-CPU29 USPP 3G2S6CPU29
OMRON C20-CPU54E USPP C20CPU54E
OMRON C40H-C5DTD-V1 USPP C40HC5DTDV1
OMRON CS1W-SCU21-V1 NSFP CS1WSCU21V1
OMRON 3G2S6-CPU25 USPP 3G2S6CPU25
OMRON 3G3MV-AB007 USPP 3G3MVAB007
Omron V740-HS03L RFID Reader Writer Antenna * 30 DAY GUARANTEE *
17 units available... the lowest price on the internet
OMRON V620-CD1D NSFP V620CD1D
C200H-AD001 Omron PLC New In Box Analog In C200HAD001
FQM1-MMP21 Omron PLC New In Box 2-Axis Pulse FQM1MMP21
FQM1-MMA21 Omron PLC New In Box 2-Axis Analog FQM1MMA21
V600-CA1A-N Omron New In Box RFID Controller V600CA1AN
Omron F150 Vision Mate Controller. P/N: F150-C10E. RS-232C, 24VDC, 0.5A W
C200H-MAD01 Omron PLC New In Box Analog I/O C200HMAD01
OMRON C500-OA225 USPP C500OA225
OMRON CV1000-DM151 USPP CV1000DM151
Omron NT31C-ST143B-EV3 HMI (NT31CST143BEV3) Interactive Display
ES100X-AAHFB Omron Digital Temperature Process Controller ES100XAAHFB PLC
OMRON C28K-CAR-A USPP C28KCARA
OMRON C500-ASC02 USPP C500ASC02
OMRON C500-ID411 NSFP C500ID411
OMRON V550-A20-X NSFP V550A20X
OMRON C200H-CT001-V1 USPP C200HCT001V1
OMRON SYSMAC C60H-C3DR-D-V1 PROGRAMMABLE CONTROLLER
Omron Interactive Display NT31-ST121B-EV2
Omron NT31C - ST141B - EV2 Operator Interface Panels
Omron F150-S1A Machine Vision Camera
OMRON TP100 MAINTENANCE PRODUCTIVITY MONITOR NEW
New Omron PLC CQM1H-CPU51
Omron Sysdrive 3G3JV - A4007 Inverter
OMRON C28K-CAS1A NSFP C28KCAS1A
OMRON F30E CAMERA
OMRON CV500-IC301 NSFP CV500IC301
OMRON NT20M-LK203-EV1 NSFP NT20MLK203EV1
OMRON C200HW-DRM21-V1 NSPP C200HWDRM21V1
Omron Sysmac C40K-CAR-A Programmable Controller
OMRON C500-RM001-PEV1 USPP C500RM001PEV1
Omron PLC CJ1G-CPU42H CJ1GCPU42H New in Box Free Ship
OMRON CPM2A-60CDR-D USPP CPM2A60CDRD
OMRON F300-KP NSFP F300KP
OMRON CQM1-CPU41-V1 USPP CQM1CPU41V1
Omron F3W-C044 Photoelectric Switch
OMRON C200H-CT002 NSFP C200HCT002
OMRON C28P-EDR-A NSPP C28PEDRA
OMRON 3G2C5-BC001 USPP 3G2C5BC001
OMRON Z3SPM08B1D1 USPP Z3SPM08B1D1
Omron C200H-PS221, New, C200HPS221, Fast Shipping
Omron CQM1H-CPU11, New, CQM1HCPU11, Fast Shipping
Omron CQM1-OC224, New, CQM1OC224, Fast Shipping
Omron H8PR-16, New, H8PR16, Fast Shipping
OMRON F10-C35 USPP F10C35
CHARMILLES POWER SUPPLY OMRON S82P-1024 S82P1024 1024 \
Omron Interactive Display NT31-ST121B-EV2 (15)
Omron R88D-WT02H Servo w/ R88M-W20030H Motor + cables (31-H)
Omron R88D-WT01H Servo w/ R88M-W10030H-B Motor + cables (31-H)
10) V600-D23P66SP Omron New In Box RFID Tag V600D23P66SP
Omron NT 10S-5F121 Interactive Display
R88M-U10030HA-BS1 Omron New In Box Servo Motor R88MU10030HABS1
OMRON V600CA2A IDENTIFICATION SYSTEM CONTROLLER
1 NEW OMRON C200H-CPU01-E CPU MODULE PROGRAMMABLE CONTROLLER . U2-3.
CS1W-AD081-V1 Omron PLC New In Box 8 Analog CS1WAD081V1
Omron NT20S Type NT20S-ST121-V1 Programmable Terminal
OMRON C200H-MAD01 NIB Free Ship
Omron CS1W-NC213 Free Ship
New Omron RFID System Controller V600-CA1A-V2
OMRON C40H-C6DR-DE-V1 USPP C40HC6DRDEV1
OMRON 3G2C7-MC22C NSFP 3G2C7MC22C
OMRON 3G2S6-CPU15 USPP 3G2S6CPU15
New Omron PLC C200H-DA004
OMRON 3G2C7-MC224 NSFP 3G2C7MC224
OMRON C200H-CPU03E NSFP C200HCPU03E
OMRON CV500-SLK21 NSPP CV500SLK21
OMRON CS1W-AD081-V1 USPP CS1WAD081V1
OMRON CS1W-DA08C USPP CS1WDA08C
Omron Sysmac C200H-PR027E Programming Console
OMRON LASER DISPLACEMENT SENSOR Z4M-T30V2 SENSOR HEAD Z4M-H30V CABLE Z49-C11
Omron CPM2A 40CDT D Controller
Omron C28K-CAS1-A/C28KCAS1A Brand New!!!!!!
Omron CS1H-CPU63H CPU Unit w/ CS1W-SCB21-V1 Serial Comm CS1H-CPU63-H CS1HCPU63H
Omron Safety Light Curtain F3SJ-A0320P30-L ! WOW !
Omron Safety Light Curtain F3SJ-A0320P30-D ! WOW !
OMRON R88M-U10030LA NSFP R88MU10030LA
OMRON C200H-T001/C200HTC001 Brand New!!!
OMRON C40P-EDR-A NSFP C40PEDRA
在線咨詢 
在線客服：0571-87774297
